+高级检索
脉冲磁控溅射MoS2涂层的组织结构及摩擦学性能
DOI:
作者:
作者单位:

核工业西南物理研究院

作者简介:

通讯作者:

中图分类号:

基金项目:

四川省青年科技创新研究团队专项计划项目(项目号2016TD0015)


Structure and Tribological Properties of MoS2 Films Deposited by Unipolar Pulse Magnetron Sputtering
Author:
Affiliation:

South western Institute of Physics

Fund Project:

The project was supported by Sichuan Municipal Technical Innovation Fund for Youth, China (2016TD0015)

  • 摘要
  • |
  • 图/表
  • |
  • 访问统计
  • |
  • 参考文献
  • |
  • 相似文献
  • |
  • 引证文献
  • |
  • 资源附件
  • |
  • 文章评论
    摘要:

    采用单极性脉冲磁控溅射技术在A286基体表面制备MoS2低摩擦系数涂层(LFC)。利用XRD、SEM等手段表征涂层的成分与微观组织;采用原位纳米力学测试系统、球-盘式摩擦磨损试验机分析涂层的力学和摩擦学性能,并探讨了脉冲偏压对涂层结构、力学和摩擦学性能的影响。结果表明,脉冲偏压由300V增加到600V,MoS2涂层择优取向发生了(002)向(100)转变,当脉冲偏压增至800V时又恢复(002)择优取向,;随着脉冲偏压的增加,涂层的硬度及弹性模量出现先减少后增大趋势,摩擦系数在0.065~0.076范围内波动,呈现出先增加后减小趋势;偏压为800V的涂层摩擦学性能最佳,其磨损率仅为基体的13.5%。

    Abstract:

    MoS2 films wre prepared on A286 substrate by unipolar pulse magnetron sputtering. The morphology,microstructure and composition of the films were characterized by using scanning electron microscopy, X-ray diffractometer. The mechanical properties and tribological behavior in air of the films were investigated by using nano-indentation tester and ball-on-disc tribotester. This paper discusses effects of pulsed bias on microstructure, mechanical properties and tribological properties of MoS2 Films. The results show that the preferential oriention of coatings changes from (002) to (100) in advance with the pulse bias voltage increasing from 300 V to 600 V. When the pulse bias voltage increasing to 800V, the preferential oriention renews to (002), and the film was of smooth and compact structure.With the pulse bias voltage increasing, the hardness and elastic modulus will decrease firstly and increase afterward. The friction coefficient fluctuated in the range of 0.065~0.076 and show the tendency of increasing firstly and decreasing afterward. When the bias voltage is 800 V, the property and performance of friction is the best. The wearing rate is only 13.5% of the substrate, It shows the lower friction coeffient and the good wearing resistance.

    参考文献
    相似文献
    引证文献
引用本文

但敏,罗蓉蓉,周毅,李建,金凡亚.脉冲磁控溅射MoS2涂层的组织结构及摩擦学性能[J].稀有金属材料与工程,2019,48(8):2716~2722.[DAN Min, LUO Rong-rong, ZHOU Yi, LI Jian, JIN Fan-ya. Structure and Tribological Properties of MoS2 Films Deposited by Unipolar Pulse Magnetron Sputtering[J]. Rare Metal Materials and Engineering,2019,48(8):2716~2722.]
DOI:[doi]

复制
文章指标
  • 点击次数:
  • 下载次数:
  • HTML阅读次数:
  • 引用次数:
历史
  • 收稿日期:2018-03-21
  • 最后修改日期:2018-04-03
  • 录用日期:2018-05-18
  • 在线发布日期: 2019-09-05
  • 出版日期: