+Advanced Search
Influence of pre-deformation on aging precipitation and mechanical properties of Cu-Ag alloy
Author:
Affiliation:

Key Laboratory of Electromagnetic Processing of Materials Ministry of Education,Northeastern University,Shenyang

  • Article
  • | |
  • Metrics
  • |
  • Reference [22]
  • |
  • Related [20]
  • | | |
  • Comments
    Abstract:

    Cu-Ag alloy is a kind of high-strength and high-conductivity alloy with important application prospects. The improvement of the properties of Cu-Ag alloy depends on the development of the deformation and heat-treatment process. However, the effect of pre-deformation before the heat treatment has not been investigated. The effects of pre-deformation on microstructure and properties after solid solution were investigated using XRD analysis, Vickers hardness, conductivity, metalloscope and scanning electron microscopy. The results show that pre-deformation promotes the recrystallization of Cu-6Ag alloy, and the grain size is obviously reduced. Meanwhile, the pre-deformation reduces the amount of Ag in Cu-6 wt% Ag alloy after aging treatment. Discontinuous precipitates are observed in samples with or without pre-deformation. The discontinuous precipitation in the pre-deformed alloy has a smaller spacing of 95±9.5nm. The hardness in pre-deformation alloy is 85.8 HV lower than that in unpre-deformation alloy. The conductivity of pre-deformed alloy is almost equal to unpre-deformation alloy which is, 90.3%IACS.

    Reference
    [1] Hirota T, A Imai, T Kumano, et al. IEEE Transactions on Magnetics[J], 1994, 30(4): 1891
    [2] Freudenberger J, H J Klau?, K Heinze, et al. International Journal of Fatigue[J], 2008, 30: 437
    [3] Han K, A Baca, H Coe, et al. IEEE Transactions on Applied Superconductivity[J], 2000, 10(1): 1277
    [4] Sakai Y, H J Schneider-Muntau. Acta Mater.[J], 1997, 45(3): 1017
    [5] Sakai Y, K Inoue, H Maeda. IEEE Trans. Magn.[J], 1994, 30(4): 2114
    [6] Han K, J D Embury, J R Sims, et al. Mater. Sci. Eng. A[J], 1999, 267(1): 99
    [7] Zhang B B, N R Tao, K Lu. Scripta Mater.[J], 2017, 129: 39
    [8] Li R, X Zuo, E Wang. J. Alloys Compd.[J], 2019, 773: 121
    [9] Liu J B, L Zhang, A P Dong, et al. Mater. Sci. Eng. A[J], 2012, 532: 331
    [10] Gaganov A, J Freudenberger, E Botcharova, et al. Mater. Sci. Eng. A[J], 2006, 437(2): 313
    [11] Zhao C, R Niu, Y Xin, et al. Mater. Sci. Eng. A[J], 2021, 799: 140091
    [12] An B, Y Xin, R Niu, et al. Mater. Lett.[J], 2019, 252: 207
    [13] Mao Q, Y Zhang, J Liu, et al. Nano Lett.[J], 2021, 21(7): 3191
    [14] 张生龙, 尹志民. 材料导报[J], 2003, (11): 26
    [15] Liu P, B X Kang, X G Cao, et al. MATERIALS SCIENCE AND ENGINEERING A-STRUCTURAL MATERIALS PROPERTIES MICROSTRUCTURE AND PROCESSING[J], 1999, 265(1-2): 262
    [16] Sakai Y. MRS Adv.[J], 2016, 1(17): 1137
    [17] Fatemi-Varzaneh S M, A Zarei-Hanzaki, J M Cabrera, et al. MATERIALS CHEMISTRY AND PHYSICS[J], 2015, 149: 339
    [18] 周玉, 武高辉, 哈尔滨工业大学出版社[M]1998.
    [19] 宝鸡有色金属研究所, 冶金工业出版社[M]1978.
    [20] Xie M, P Zhou, W Huang, et al. Mater. Sci. Eng. A[J], 2022, 840: 143004
    [21] An B, Y Xin, R Niu, et al. Materials Research Express[J], 2022, 9(2): 026530
    [22] 林剑, 张进东, 孟亮. 稀有金属材料与工程[J], 2008, 37(7): 5
    Cited by
    Comments
    Comments
    分享到微博
    Submit
Get Citation

[Du Jingwen, An Bailing, Zhang lin, Wang Engang. Influence of pre-deformation on aging precipitation and mechanical properties of Cu-Ag alloy[J]. Rare Metal Materials and Engineering,2023,52(1):403~408.]
DOI:10.12442/j. issn.1002-185X.20220329

Copy
Article Metrics
  • Abstract:456
  • PDF: 1045
  • HTML: 65
  • Cited by: 0
History
  • Received:April 19,2022
  • Revised:August 28,2022
  • Adopted:September 22,2022
  • Online: February 13,2023
  • Published: February 08,2023